Building a world of
resilient communities.



The Hydrogen Economy – Energy and Economic Black Hole

The energy literate scoff at perpetual motion, free energy, and cold fusion, but what about the hydrogen economy?  Before we invest trillions of dollars, let’s take a hydrogen car out for a spin.

Making it

Hydrogen isn’t an energy source – it’s an energy carrier, like a battery.  You have to make it and put energy into it, both of which take energy.  Ninety-six percent is made from fossil fuels, mainly for oil refining and partially hydrogenated oil--the kind that gives you heart attacks (1).    In the United States, ninety percent is made from natural gas, with an efficiency of 72% (2), which means you've just lost 28% of the energy contained in the natural gas to make it (and that doesn’t count the energy it took to extract and deliver the natural gas to the hydrogen plant).  

Only four percent of hydrogen is made from water via electrolysis.  It’s done when the hydrogen must be extremely pure.  Since most electricity comes from fossil fuels in plants that are 30% efficient, and electrolysis is 70% efficient, you end up using four units of energy to create one unit of hydrogen energy: 70% * 30% = 20% efficiency (3).

Getting hydrogen using fossil fuels as a feedstock or an energy source is a bit perverse, since the whole point is to get away from them.  The goal is to use renewable energy to make hydrogen from water via electrolysis.  When the wind is blowing, current wind turbines can perform at 30-40% efficiency, producing hydrogen at an overall 25% efficiency, or 3 units of wind energy to get 1 unit of hydrogen energy.  The best solar cells available on a large scale have an efficiency of ten percent, or 9 units of energy to get 1 hydrogen unit of energy.  If you use algae making hydrogen as a byproduct, the efficiency is about .1% (4).

No matter how you look at it, producing hydrogen from water is an energy sink.  If you don't understand this concept, please mail me ten dollars and I'll send you back a dollar.

Hydrogen can be made from biomass, but then these problems arise: 1) it’s very seasonal, 2) contains a lot of moisture, requiring energy to store and dry it before gasification,  3) there are limited supplies,  4) the quantities are not large or consistent enough for large-scale hydrogen production,  5) a huge amount of land would be required, because even cultivated biomass in good soil has a low yield -- 10 tons per 2.4 acres,  6) the soil will be degraded from erosion and loss of fertility if stripped of biomass,  7) any energy put into the land to grow the biomass, such as fertilizer and planting / harvesting will add to the energy costs, 8) delivery costs to the central power plant,  and 9) it’s not suitable for pure hydrogen production (5). 

One of the main reasons for switching to hydrogen is to prevent global warming caused by fossil fuels.  When it’s made from natural gas, nitrogen oxides are released, which are 58 times more effective in trapping heat than carbon dioxide (6).  Coal releases large amounts of CO2 and mercury. Oil is too powerful and useful to waste on hydrogen–it’s concentrated sunshine brewed over hundreds of millions of years. A gallon of gas represents about 196,000 pounds of fossil plants, the amount in 40 acres of wheat (7).

Natural gas is too valuable to make hydrogen with.  It is used to create fertilizer (as both feedstock and energy source).  This has led to a many-fold increase in crop production, allowing an additional 4 billion people to exist who otherwise wouldn’t be here  (8, 9).

We also don’t have enough natural gas left to make a hydrogen economy happen. Extraction of natural gas is declining in North America (10). It will take at least a decade to even begin replacing natural gas with imported LNG (liquid natural gas).  Making LNG is so energy intensive that it would be economically and environmentally insane to use it as a source of hydrogen (3). Putting energy into hydrogen

No matter how it’s been made, hydrogen has no energy in it.  It is the lowest energy dense fuel on earth (5). At room temperature and pressure, hydrogen takes up three thousand more times space than gasoline containing an equivalent amount of energy (3).   To put energy into hydrogen, it must be compressed or liquefied. To compress hydrogen to 10,000 psi is a multi-stage process that will lose an additional 15% of the energy contained in the hydrogen. 

If you liquefy it, you will be able to get more hydrogen energy into a smaller container, but you will lose 30-40% of the energy in the process.  Handling it requires extreme precautions because it's so cold – minus 423 F.  Fueling is typically done mechanically with a robot arm (3).   Storage

On a vehicle you’d need to have a heavy cryogenic support system if you use liquid hydrogen.  The tank is cold enough to cause plugged valves and other problems.  If you add insulation to prevent this, you will increase the weight of an already very heavy storage tank (11).

Let’s assume that a hydrogen car can go 55 miles per kg (5).   A tank that can hold 3 kg of compressed gas, will go 165 miles and weigh  400 kg / 882 lbs (12).  Compare that with a Honda Accord fuel tank that weighs 11 kg / 25 lbs, costs $100, and holds 17 gallons of gas.  The overall weight is 73 kg / 161 lbs (8 lbs per gallon). The driving range is 493 miles at 29 mpg.  

According to the National Highway Safety Traffic Administration (NHTSA), "Vehicle weight reduction is probably the most powerful technique for improving fuel economy. Each 10 percent reduction in weight improves the fuel economy of a new vehicle design by approximately eight percent”.  

The more you compress hydrogen, the smaller the tank can be.  But as you increase the pressure, you also have to increase the thickness of the steel wall, and hence the weight of the tank.  Cost increases with pressure.  At 2000 psi, it’s $400 per kg. At 8000 psi, it’s $2100 per kg (5). And the tank will be huge -- at 5000 psi, the tank could take up ten times the volume of a gasoline tank containing the same energy content. 

Fuel cells are also heavy:  "A metal hydride storage system that can hold 5 kg of hydrogen, including the alloy, container, and heat exchangers, would weigh

approximately 300 kg (661 lbs), which would lower the fuel efficiency of the vehicle," according to Rosa Young, a physicist and vice president of advanced materials development at Energy Conversion Devices in Troy, Michigan (12).

Fuel cells are expensive.  In 2003, they cost $1 million or more. At this stage, they have low reliability, need a much less expensive catalyst than platinum, can clog and lose power if there are impurities in the hydrogen, don’t last more than 1000 hours, have yet to achieve a driving range of more than 100 miles, and can’t compete with electric hybrids like the Toyota Prius, which is already more energy efficient and low in CO2 generation than projected fuel cells. (3)

Hydrogen is the Houdini of elements.  As soon as you’ve gotten it into a container, it wants to get out, and since it’s the lightest of all gases, it takes a lot of effort to keep it from escaping.  Storage devices need a complex set of seals, gaskets, and valves.  Liquid hydrogen tanks for vehicles boil off at 3-4% per day (3, 13).

Hydrogen also tends to make metal brittle (14). Embrittled metal can create leaks. In a pipeline, it can cause cracking or fissuring, which can result in potentially catastrophic failure (3).  Making metal strong enough to withstand hydrogen adds weight and cost.

Leaks also become more likely as the pressure grows higher.  It can leak from un-welded connections, fuel lines, and non-metal seals such as gaskets, O-rings, pipe thread compounds, and packings.  A heavy-duty fuel cell engine may have thousands of seals (15).  Hydrogen has the lowest ignition point of any fuel, 20 times less than gasoline.  So if there’s a leak, it can be ignited by a cell phone, a storm miles away (16), or the static from sliding on a car seat.

Leaks and the fires that might result are invisible.   Unless you walk into a hydrogen flame, sometimes the only way to know there’s a leak is poor performance.


Canister trucks ($250,000 each) can carry enough fuel for 60 cars (3, 13).  These trucks weight 40,000 kg but deliver only 400 kg of hydrogen.   For a delivery distance of 150 miles, the delivery energy used is nearly 20% of the usable energy in the hydrogen delivered. At 300 miles 40%. The same size truck carrying gasoline delivers 10,000 gallons of fuel, enough to fill about 800 cars (3).

Another alternative is pipelines.  The average cost of a natural gas pipeline is one million per mile, and we have 200,000 miles of natural gas pipeline, which we can’t re-use because they are composed of metal that would become brittle and leak, as well as the incorrect diameter to maximize hydrogen throughput. If we were to build a similar infrastructure to deliver hydrogen it would cost $200 trillion. The major operating cost of hydrogen pipelines is compressor power and maintenance (3).  Compressors in the pipeline keep the gas moving, using hydrogen energy to push the gas forward. After 620 miles, 8% of the hydrogen has been used to move it through the pipeline (17).

At some point along the chain of making, putting energy in, storing, and delivering the hydrogen, you’ve used more energy than you get back, and this doesn’t count the energy used to make fuel cells, storage tanks, delivery systems, and vehicles (17).  When fusion can make cheap hydrogen, reliable long-lasting nanotube fuel cells exist, and light-weight leak-proof carbon-fiber polymer-lined storage tanks / pipelines can be made inexpensively, then let’s consider building the hydrogen economy infrastructure.  Until then, it’s vaporware.  All of the technical obstacles must be overcome for any of this to happen (18).  Meanwhile, we should stop the FreedomCAR and start setting higher CAFE standards (19).

Some time in the future, the price of oil and natural gas will go up relentlessly due to geological depletion and political crises in extracting countries.  Since the hydrogen infrastructure will be built using the existing oil-based infrastructure (i.e. internal combustion engine vehicles, power plants and factories, plastics, etc), the price of hydrogen will go up as well -- it will never be cheaper than fossil fuels.  As depletion continues, factories will be driven out of business by high fuel costs (20, 21, 22) and the parts necessary to build the extremely complex storage tanks and fuel cells might become unavailable.  In a society that’s looking more and more like Terry Gilliam’s “Brazil”, hydrogen will be too leaky and explosive to handle.

The laws of physics mean the hydrogen economy will always be an energy sink.  Hydrogen’s properties require energy to overcome waters’ hydrogen-oxygen bond, to move heavy cars, to prevent leaks and brittle metals, to transport to the destination.

Any diversion of declining fossil fuels to a hydrogen economy subtracts that energy from other possible uses, such as planting, harvesting, delivering, and cooking food, heating homes, and other essential activities.   According to Joseph Romm  “The energy and environmental problems facing the nation and the world, especially global warming, are far too serious to risk making major policy mistakes that misallocate scarce resources (3).


 (1) Michael F. Jacobson  Waiter, please hold the hydrogen
 (2) Martin I.Hoffert, et al "Advanced Technology Paths to Global Climate Stability:  Energy for a Greenhouse Planet"  SCIENCE     VOL 298      1 November 2002
 (3) Joseph J. Romm - The Hype About Hydrogen: Fact & Fiction in the Race to Save the Climate 2004
 (4) Howard Hayden - The Solar Fraud: Why Solar Energy Won't Run the World 
 (5) D.Simbeck and E.Chang - Hydrogen Supply: Cost Estimate for Hydrogen Pathways - Scoping Analysis- National Renewable Energy Lab
 (6) Union of Concerned Scientists
 (7) What's in a Gallon of Gas?
 (8) David & Marshall Fisher - The Nitrogen Bomb   April 2001
 (9) Vaclav Smil  Scientific American Jul 1997 Global Population & the Nitrogen Cycle
(10) Julian Darley - High Noon for Natural Gas: - The New Energy Crisis 2004
(11) Rocks in your Gas Tank
(12)  fill'er up—with hydrogen    Mechanical Engineering Magazine
(13) Wade A. Amos -  Costs of Storing and Transporting Hydrogen - U.S. Department of Energy Energy Efficiency and Renewable Energy
(14) Omar A. El kebir, Andrzej Szummer - Comparison of hydrogen embrittlement of stainless steels and nickel-base alloys - International Journal of Hydrogen Energy - Volume: 27, Issue: 7-8  July - August, 2002
(15) Fuel Cell Engine Safety - U.S. Department of Energy - Energy Efficiency and Renewable Energy
(16) Dr. Joseph Romm  Testimony for the Hearing Reviewing the Hydrogen Fuel and - FreedomCAR Initiatives, Submitted to the House Science Committee
(17) Ulf Bossel and Baldur Eliasson - Energy and the Hydrogen Economy
(18) National Hydrogen Energy Roadmap - Production, Delivery, Storage, Conversion, Applications, Public Education and Outreach
(19) Dan Neil  - Rumble Seat -: Toyota's spark of genius,0,7911314.story
(20) Jul 02, 2004  Oil prices raising costs of offshoots - By Associated Press
(21) May 24, 2004 Soaring energy prices dog rosy U.S. farm economy
(22) March 17, 2004 Chemical Industry in Crisis: Natural Gas Prices Are Up, Factories Are Closing, And Jobs Are Vanishing

What do you think? Leave a comment below.

Sign up for regular Resilience bulletins direct to your email.

Take action!  

Find out more about Community Resilience. See our COMMUNITIES page
Start your own projects. See our RESOURCES page.
Help build resilience. DONATE NOW.


This is a community site and the discussion is moderated. The rules in brief: no personal abuse and no climate denial. Complete Guidelines.

2014 biggest year ever for solar, but oil price threat looms

Will only time tell whether it will be enough to keep solar panels cheap …

Rethink the Grid: Personal Power Stations

Rethinking the grid is quickly emerging as one of the hottest topics.

Goldilocks Is Dead

For oil, the Goldilocks zone has ceased to exist. This will have staggering …

US enters undulating crude oil production plateau in 2015

Feel-good-outlooks make the TV audience happy, but sleepy.

Global Shale Fail: Oil Majors Leaving Fracking Fields Across Europe, Asia

As Post Carbon Institute has pointed out in two major reports, estimated …

Peak Oil Review - Mar 23

A weekly review including Oil and the Global Economy, The Middle East & …

Cheap oil, complexity and counterintuitive conclusions

The chief intellectual challenge of our age is that we live in complex …